В наши дни очень актуально применение электрического теплого пола, преимущественно при подогреве керамической плитки, обогреве лоджии, бани либо веранды. Также такие полы используют как дополнение к основному виду отопления. Укладка такого пола достаточно проста, если следовать инструкциям.
Схема теплого электрического пола
Структуру электрического пола начиная от нижнего слоя следующая:
- основной черновой пол из бетона, который необходимо выполнять максимально ровно, без впадин и бугорков, чтобы не пережечь кабель;
- теплоизолирующая неплавкая подложка под электрический пол, например, пенополистирол либо пенополиэтилен с отражающим слоем из фольги толщину, которой подбирают соответственно температурным нагрузкам;
- крепежная система, представляющая собой монтажную ленту либо арматурную сетку;
- нагревательный кабель с наличием температурного датчика, который подает информацию на терморегулятор;
- заливка специальной смеси для теплых полов либо цементно-песочная стяжка толщиной около 3-5 сантиметров;
- напольное финишное покрытие, в большинстве случаев плитка, но возможна прокладка и иного покрытия.
Материалы
Электрический теплый пол бывает двух разновидностей :
- Пол, который сформирован методом самостоятельной укладки кабеля нагревания.
- Пол с нагревательными матами, то есть стеклосетка, в которой имеется уже проложенный кабель.
Принципиального отличия между этими разновидностями нет. В первом случае имеется свобода режима обогрева и расположения кабеля, а также возможность использования нагревательного кабеля, как для основной, так и для дополнительной системы отопления. Маты же, как правило, используют для дополнительного обогрева.
Кабели в свою очередь бывают резистивные и саморегулирующиеся.Резистивный состоит из одной либо двух жил, которые обладают повышенным сопротивлением. Он также называется одножильным либо двужильным.
Двужильные кабели довольно просты в монтаже и оборудованы системой рассеивания электромагнитного излучения намного лучше. Саморегулирующийся кабель немного отличается по конструкции.
В данном случае, исходя из своей конструкции, по всей длине кабеля происходит процесс самостоятельной регуляции силы тока, влияющей на нагревательный элемент. Благодаря этому кабель не перегревается на каком-либо участке и не нарушает систему обогрева, в отличие от кабеля первого типа. Однако такой вариант обходится дороже по цене.
Порядок работы
При формировании электрического пола важен правильный расчет мощности системы обогрева для конкретного помещения. Также температуру пола следует учесть при подборе покрытия пола. Общие данные для помещений различного типа следующие:
- в спальне — 100 -150 Вт/кв.м;
- в коридоре, кухне и прихожей комнате — 150 Вт/кв.м;
- в ванной и туалете — 180 Вт/кв.м;
- на балконе или в лоджии — 200 Вт/кв.м.
Так или иначе рекомендуется обратиться к услугам специалиста, который точно определит нужную мощность и поможет подобрать нужные материалы. Таким же образом должна составляться схема электрического теплового пола. Участие специалиста также необходимо при подключении системы и проведении от распределительного щита дополнительной усиленной линии проводки. Монтажные работы же можно проводить самостоятельно.
Выравнивание полов и укладка теплоизоляции
В случае, если теплый пол служит в качестве основного источника обогрева следует обязательно применить слой теплоизоляции, толщина которого зависит от того, что уложено непосредственно под покрытием пола. Лучше всего для этого подходит пенополистирол 35-ой плотности. Для помещений выше первого этажа при наличии внизу отапливаемого помещения достаточно применить утеплитель толщиной 2 сантиметра. Для помещений же первого этажа с наличием отапливаемого подвала рекомендуется применение утеплителя толщиной 3 сантиметра. Для помещений первого этажа без отапливаемых подвалов, балконов, а также помещений, находящихся над арочными сквозными пролетами следует использовать утеплитель толщиной не менее 5 сантиметров, а в домах с бетонной подушкой, лежащей на грунте – 10 сантиметров.
Слой теплоизоляции можно прикрепить при помощи специальных дюбелей либо уложить на специальный клей. Полы необходимо делать ровными, без ям, трещин и перекосов. В обратном случае трещины заделываются цементным раствором, а при перекосе делается черновая стяжка и выравнивается пол. Перед укладкой теплоизоляции поверхность обрабатывается грунтовкой, которая препятствует образованию плесени, а при склеивании слоя теплоизоляции благодаря грунтовке повышается сцепление материалов между собой. Плиты клеятся либо закрепляются в нескольких местах посредством дюбелей. По поверхности фиксируют штукатурную сетку при помощи пластиковых плит либо дюбелей с шайбами, равными по длине толщине слоя теплоизоляции. Такой крепеж дополнительно прикрепляет к полу плиты.
Расчет кабеля
Кабель должен покрывать поверхность помещения на 80% площади всего помещения. На 1 квадратный метр закладывается мощность в рамках 180-200 Вт/ м². Необходимо до укладки проверить сопротивление секций кабеля. Допустимо отклонение около 10% в обе стороны от показателя, указанного в техпаспорте. Кабель не прокладывается в местах нахождения бытовой техники, крупногабаритной мебели без опорных ножек. От стен отступают на 5-7 сантиметров. Далее рассчитывается шаг для укладки кабеля. В сантиметрах шаг равняется площади обогрева, умножаемой на 100 и делимой на длину кабеля. До укладки кабеля следует учесть то, что секция одножильного кабеля соединяется с нагревательным проводом в двух концах, а у двужильного кабеля с одного.
Подготовительные работы
Чтобы установить терморегулятор в стене на месте крепления вырезается углубление и проделывается штроба до пола. Посредством алебастра крепят монтажную коробку для терморегулятора. Из нее выходит гофрированная трубка, которая укладывается в штобру и замазывается алебастром. Конец трубки на 40 сантиметров заводят в зону обогрева, расположив ее так, чтобы термодатчик находился между витками кабеля в центре. У трубы не должно быть резких изгибов. Под ее конец, на место расположения датчика, подкладывается материал для возвышения для того, чтобы датчик находился почти под полом, правильно фиксируя температуру. Трубку на конце следует плотно закрыть с помощью изоленты для предотвращения попадания в нее раствора при стяжке.
Укладка кабеля
Кабель располагают змейкой, при этом соблюдают вычисленный шаг. Можно зафиксировать его к металлической сетке при помощи пластиковых стяжек минимальной длины. Затем после укладки проверяется и записывается сопротивление кабеля, зарисовывается схема расположения витков кабеля, включается и проверяется работоспособность системы. После этого все отключается, снимается терморегулятор до завершения работ по отделке пола.
I’ve recently started a site, the information you provide on this website has helped me tremendously. Thanks for all of your time & work.
I wanted to create you that tiny remark in order to thank you so much as before on your lovely tactics you have contributed in this case. It has been certainly generous with people like you to offer extensively what a number of people would have advertised as an e-book to get some profit on their own, notably since you could have tried it if you ever wanted. Those tricks as well acted to provide a fantastic way to understand that many people have similar eagerness just as my own to see a great deal more around this issue. I believe there are millions of more enjoyable times ahead for many who browse through your blog post.
Hello! This post could not be written any better! Reading through this post reminds me of my good old room mate! He always kept talking about this. I will forward this write-up to him. Fairly certain he will have a good read. Thank you for sharing!
Hello! This is kind of off topic but I need some help from an established blog. Is it very difficult to set up your own blog? I’m not very techincal but I can figure things out pretty quick. I’m thinking about setting up my own but I’m not sure where to begin. Do you have any tips or suggestions? Appreciate it
We are a group of volunteers and opening a new scheme in our community. Your website provided us with valuable info to work on. You’ve done a formidable job and our entire community will be grateful to you.
I know this if off topic but I’m looking into starting my own weblog and was curious what all is required to get set up? I’m assuming having a blog like yours would cost a pretty penny? I’m not very internet smart so I’m not 100 certain. Any suggestions or advice would be greatly appreciated. Thank you
I must show thanks to this writer just for rescuing me from such a instance. Because of surfing throughout the search engines and meeting methods which were not beneficial, I figured my life was over. Living devoid of the solutions to the difficulties you’ve sorted out by way of the write-up is a critical case, and ones that might have in a wrong way affected my entire career if I hadn’t noticed your web site. Your main talents and kindness in handling every part was helpful. I don’t know what I would have done if I had not discovered such a subject like this. I can also at this moment look ahead to my future. Thanks a lot so much for your impressive and results-oriented guide. I won’t be reluctant to propose your web sites to any person who needs to have counselling on this topic.
I have been examinating out many of your articles and it’s pretty nice stuff. I will definitely bookmark your site.
This really answered my downside, thanks!
It’s exhausting to find knowledgeable people on this matter, but you sound like you understand what you’re speaking about! Thanks
What i do not realize is actually how you’re not actually much more well-liked than you might be now. You’re so intelligent. You realize therefore considerably relating to this subject, made me personally consider it from a lot of varied angles. Its like women and men aren’t fascinated unless it is one thing to do with Lady gaga! Your own stuffs great. Always maintain it up!
Its like you read my mind! You seem to know a lot approximately this, like you wrote the e book in it or something. I believe that you just can do with a few to drive the message house a bit, but other than that, this is excellent blog. A fantastic read. I’ll definitely be back.
Good day! This is my 1st comment here so I just wanted to give a quick shout out and say I truly enjoy reading your articles. Can you recommend any other blogs/websites/forums that go over the same topics? Thank you so much!
Wow, marvelous blog layout! How long have you been blogging for? you make blogging look easy. The overall look of your site is magnificent, let alone the content!
I precisely wanted to appreciate you all over again. I am not sure the things I would have handled without the entire thoughts shown by you on this area. This was a real daunting concern in my circumstances, however , viewing your specialized fashion you solved that took me to leap with delight. I will be grateful for this service and then hope you comprehend what an amazing job you’re getting into instructing the others thru your website. I know that you’ve never encountered all of us.
Nice post. I used to be checking continuously this blog and I am impressed! Very useful info specially the last phase 🙂 I handle such info much. I was seeking this particular info for a very long time. Thank you and good luck.
I and my guys were looking at the excellent ideas located on the blog and then suddenly I got a terrible suspicion I had not thanked the blog owner for those tips. All of the boys are actually absolutely joyful to see all of them and have now surely been tapping into these things. Thanks for being really helpful and for having certain perfect subject areas most people are really desperate to be aware of. Our sincere apologies for not expressing appreciation to you earlier.
I don’t even know how I ended up right here, but I assumed this post was great. I don’t understand who you are however certainly you’re going to a well-known blogger should you are not already 😉 Cheers!
Please let me know if you’re looking for a writer for your site. You have some really great articles and I believe I would be a good asset. If you ever want to take some of the load off, I’d really like to write some content for your blog in exchange for a link back to mine. Please blast me an email if interested. Kudos!
Thank you, I’ve just been searching for information about this topic for ages and yours is the greatest I have discovered so far. But, what about the bottom line? Are you sure about the source?
When I originally commented I clicked the «Notify me when new comments are added» checkbox and now each time a comment is added I get several emails with the same comment. Is there any way you can remove people from that service? Bless you!
Pretty great post. I simply stumbled upon your weblog and wished to say that I’ve really loved browsing your weblog posts. In any case I’ll be subscribing to your feed and I hope you write again soon!
I am just commenting to make you know what a helpful discovery my wife’s princess developed going through the blog. She noticed plenty of things, including what it is like to possess an amazing helping style to get many people without hassle fully grasp specific specialized matters. You actually did more than our own expected results. I appreciate you for coming up with the insightful, healthy, edifying and in addition cool tips about the topic to Kate.
I’ve read some good stuff here. Certainly worth bookmarking for revisiting. I wonder how much effort you put to create such a great informative website.
Hey! I just would like to give an enormous thumbs up for the good data you have here on this post. I can be coming back to your weblog for extra soon.
There are some interesting time limits in this article however I don’t know if I see all of them center to heart. There’s some validity but I will take hold opinion until I look into it further. Good article , thanks and we would like extra! Added to FeedBurner as well
I do not even know how I ended up here, but I thought this post was good. I do not know who you are but definitely you are going to a famous blogger if you are not already 😉 Cheers!
The very crux of your writing while appearing reasonable initially, did not really sit very well with me after some time. Somewhere throughout the sentences you actually were able to make me a believer unfortunately only for a very short while. I still have got a problem with your jumps in assumptions and you would do well to help fill in those breaks. If you can accomplish that, I would definitely end up being amazed.
I am continuously browsing online for tips that can facilitate me. Thanks!
It’s appropriate time to make some plans for the future and it’s time to be happy. I’ve read this post and if I could I desire to suggest you few interesting things or suggestions. Maybe you could write next articles referring to this article. I desire to read more things about it!
There is noticeably a bundle to realize about this. I suppose you made various good points in features also.
I was wondering if you ever considered changing the page layout of your site? Its very well written; I love what youve got to say. But maybe you could a little more in the way of content so people could connect with it better. Youve got an awful lot of text for only having 1 or 2 pictures. Maybe you could space it out better?
Hello there! Do you know if they make any plugins to assist with Search Engine Optimization? I’m trying to get my blog to rank for some targeted keywords but I’m not seeing very good success. If you know of any please share. Appreciate it!
I don’t even know how I ended up here, but I thought this post was good. I do not know who you are but definitely you’re going to a famous blogger if you are not already 😉 Cheers!
I have been exploring for a little bit for any high quality articles or weblog posts in this kind of space . Exploring in Yahoo I finally stumbled upon this site. Studying this info So i am satisfied to show that I’ve a very just right uncanny feeling I came upon just what I needed. I so much unquestionably will make certain to don’t omit this site and give it a look on a continuing basis.
hi!,I like your writing so much! share we communicate more about your post on AOL? I need an expert on this area to solve my problem. Maybe that’s you! Looking forward to see you.
I will right away grab your rss as I can’t to find your e-mail subscription hyperlink or e-newsletter service. Do you have any? Please allow me recognise so that I may just subscribe. Thanks.
Greetings from Los angeles! I’m bored to death at work so I decided to browse your blog on my iphone during lunch break. I love the knowledge you present here and can’t wait to take a look when I get home. I’m shocked at how fast your blog loaded on my mobile .. I’m not even using WIFI, just 3G .. Anyways, fantastic site!
I carry on listening to the newscast talk about receiving boundless online grant applications so I have been looking around for the most excellent site to get one. Could you advise me please, where could i get some?
There are some attention-grabbing deadlines in this article but I don’t know if I see all of them middle to heart. There is some validity but I’ll take maintain opinion till I look into it further. Good article , thanks and we wish more! Added to FeedBurner as nicely
Hey There. I found your blog using msn. This is an extremely well written article. I will be sure to bookmark it and return to read more of your useful info. Thanks for the post. I’ll definitely comeback.
You can definitely see your expertise in the work you write. The world hopes for more passionate writers like you who are not afraid to say how they believe. Always go after your heart.
I am not positive where you are getting your info, but great topic. I needs to spend some time finding out much more or figuring out more. Thanks for magnificent info I used to be on the lookout for this information for my mission.
When I originally commented I clicked the -Notify me when new comments are added- checkbox and now each time a comment is added I get four emails with the same comment. Is there any method you possibly can take away me from that service? Thanks!
Thank you for the auspicious writeup. It in fact was a amusement account it. Look advanced to more added agreeable from you! However, how can we communicate?
Have you ever thought about adding a little bit more than just your articles? I mean, what you say is valuable and everything. However imagine if you added some great visuals or videos to give your posts more, «pop»! Your content is excellent but with pics and video clips, this website could certainly be one of the greatest in its niche. Very good blog!
What’s Happening i’m new to this, I stumbled upon this I have discovered It absolutely helpful and it has helped me out loads. I am hoping to give a contribution & aid different users like its helped me. Great job.
I precisely wanted to appreciate you again. I am not sure the things that I would have followed in the absence of these tactics provided by you about such industry. This has been an absolute difficult issue in my position, nevertheless observing a new specialized mode you managed it forced me to leap for happiness. Extremely thankful for this help as well as sincerely hope you know what a powerful job you have been accomplishing educating the others through your blog post. I am sure you have never come across all of us.
A powerful share, I just given this onto a colleague who was doing a little evaluation on this. And he the truth is bought me breakfast as a result of I found it for him.. smile. So let me reword that: Thnx for the treat! However yeah Thnkx for spending the time to discuss this, I really feel strongly about it and love reading more on this topic. If possible, as you turn out to be expertise, would you mind updating your blog with more details? It’s extremely helpful for me. Huge thumb up for this blog post!
My brother suggested I would possibly like this web site. He was once entirely right. This publish truly made my day. You can not believe simply how so much time I had spent for this information! Thank you!